Evaluation of the effect of xanthan gum and chia seed flour on the physical stability and textural and rheological properties of dairy spread containing samanou powder

Document Type : Complete scientific research article

Authors

1 Faculty of Food Science, Gorgan University of Agricultural Sciences and Natural Resources, Gorgan, Iran

2 Department of Food Science, Faculty of Food Science, Gorgan University of Agricultural Science and Natural Resources

Abstract

Abstract
Background and objectives: Dairy Spreads are solid and spreadable food products that merely made from milk or milk products that contain 10 to 80% milk fat. samanou is a traditional Iranian dessert that is prepared by cooking a mixture of wheat flour and green malt extract. The aim of this study was to assessment the effect of adding xanthan gum (0, 0.5 and 1%) and chia seed (0, 0.5 and 1%) on physical stability and textural and rheological properties dairy spread containing samanou powder.
Material and methods: In the present study, the frequency sweep rheological test was performed by a rheometer. During this test, first the linear viscoelastic range is determined and then in the frequency range of 0.1 to 100 Hz, temperature of 10 ° C and constant strain of 1%, the rheological properties of the spread including storage modulus (G′), loss modulus (G′′) and loss tangent (G′′ /G′) were measured. Emulsion stability was measured using a centrifuge based on oil separation (g). texture evaluation was performed by backward extrusion and spreadability tests with a texture analyzer to determine of firmness (N), cohesievness (N), consistency (Ns) and spreadability (N) parameters.
Results: The results showed that the effect of adding xanthan gum and chia seed flour on increasing the cohesievness, consistency, firmness and reducing the spreadability of the produced spread was significant (p<0.05). Increasing the concentration of xanthan and chia seed flour from zero to 1% increased the cohesiveness and firmness and also redused the spreadability of the produced spread compared to the control sample. The treatment containing 1% xanthan and 1% chia seed flour had the highest firmness and the least spreadability, respectively. spreads containing xanthan were more consistency than spreads containing chia seed flour, so the highest and lowest consistency were in the treatment containing 1% xanthan and without chia seed flour (67.53±12.66 N.s) and the treatment prepared from 1% Chia seeds flour without xanthan of (37.36±17.5 Ns), respectively. The lowest and highest cohesievness were in the treatment containing 0.5% xanthan (-0.05±0.22 N) and the treatment containing 1% xanthan and 0.5% chia seed flour with a score of -0.31±0.39 N respectively. Spreads containing xanthan gum and chia seed flour were more stable than the control sample, so that the control sample had the highest oil separation and the lowest physical stability (0.476±0.13 gr). In frequency sweep test, 1% strain was determined as the best strain corresponding to the linear viscoelastic range. by simultaneous increasing the concentration of xanthan and chia seed flour, the amount G′, G′′ and G′′ /G′ decreased. The presence of chia seed flour in the spread formulation, unlike xanthan gum, increased the amount of G′ and G′′. The maximum amount of G′ and G′′, as a result of the highest elasticity, , consistency and , firmness belonged to the treatment containing 0.5% xanthan and the treatment containing 1% xanthan and 0.5% chia had the lowest amount of G′ and G′′ Dedicated to himself.
Conclusion: application minimum concentrations of xanthan (0.5%) and chia seed flour (0.5%)
improved the textural properties of dairy spreads containing samanou powder. Increasing the concentration of chia seed flour, unlike xanthan, weakened the internal bonds and reduced the consistency of the product. The presence of xanthan compared to chia seed flour had a greater effect on preventing phase separation and increasing the stability of dairy spread containing of samanou powder. In all frequency ranges, the amount of storage modulus was greater than the drop modulus, and the spreads produced behaved like a gel viscoelastic solid.

Keywords: Dairy spread, Samanou powder, Xanthan, chia seed flour, textural and rheological properties.

Keywords

References

  1. 1.Abdollahi, M., Goli, S.A.H., and Soltanizadeh, N. 2020. Physicochemical properties of foam-templated oleogel based on gelatin and xanthan gum. European Journal of Lipid Science and Technology. 122: 2.190-196.

    1. Abedini, N., Nasirpour, A., and Nateghi, L. 2017. Effect of xanthan gum and soy protein isolate on physicochemical properties of processed cheese. Iranian journal of food science and technology. 66:14.247-258.
    2. Alvand, A., Khoshtinat, K.H., Zandi, P., Safafar, H., Mazloomi, M., and Sharifzadeh, Z. 2007. Formulation and laboratory-scale production of low-fat and low-trans fatty acid spreads. Iranian Journal of Nutrition Sciences & Food Technology. 2:1.11-19.
    3. Amiryousefi, M.R., and Razavi, S.M. 2013. Viscous Flow Behavior, Microstructure and Physicochemical Characteristics of a Sweet Paste Functional Dessert (Samanu) Made from Germinated Wheat. Journal of Food Process Engineering, 36: 3.385-396.

    5.Ariza, E.J.S.D., Archila, A.R.B., Solchaga, I.O.S., and Pérez, S.B.M. 2020. Nutritional Composition and Uses of Chia (Salvia hispanica) in Guatemala. In Multidisciplinary Digital Publishing Institute Proceedings. 53:16.2-5.

    1. Atik, D.S., Demirci, T., Öztürk, H.İ., Demirci, S., Sert, D., and Akın, N. 2020. Chia Seed Mucilage Versus Guar Gum: Effects on Microstructural, Textural, and Antioxidative Properties of Set-Type Yoghurts. Brazilian Archives of Biology and Technology. 63: e20190702.

    7.Ayerza, R. 1995. Oil content and fatty acid composition of chia (Salvia hispanica L.) from five northwestern locations in Argentina. Journal of the American Oil Chemists’ Society. 72: 1079-1081.‏

    8.Ayerza, R.H., and Coates, W. 2004. Composition of chia (Salvia hispanica) grown in six tropical and subtropical ecosystems of South America. Tropical Science. 44:3.131-135.‏

    1. Borneo, R., Aguirre, A., and León, A.E. 2010. Chia (Salvia hispanica L.) gel can be used as egg or oil replacer in cake formulations. Journal of the American Dietetic Association. 110:6.946-949.

    10.Çiftçi, D., Kahyaoglu, T., Kapucu, S., and Kaya, S. 2008. Colloidal stability and rheological properties of sesame paste. Journal of Food Engineering. 87:3.428-435.

    11.Coorey, R., Tjoe, A., and Jayasena, V. 2014. Gelling properties of chia seed and flour. Journal of food science. 79:5.859-866.

    12.De Falco, B., Amato, M., and Lanzotti, V. 2017. Chia seeds products: an overview. Phytochemistry Reviews. 16: 4. 745-760.

    13.Dianat, M., Shahidi, F., Taghizadeh, M and ,Razavi, S.M.A. 2017. Investigation of textural and sensory properties of honey-malt spread. Iranian Journal of Nutrition Sciences & Food Technology. 64:14.311-326.

    14.Emadzadeh, B., Razavi, S.M., and Mahallati, M.N. 2012. Effects of fat replacers and sweeteners on the time-dependent rheological characteristics and emulsion stability of low-calorie pistachio butter: A response surface methodology. Food and Bioprocess Technology. 5: 5.1581-1591.

    15.Ghaderi, A., Abbasi, S., and Hamidi, Z. 2010. Yoghurt powder production using a microwave-vacuum drier. Iranian Food Science & Technology Research Journal, 6: 3. 210-222.

    16.Ghanbari, S.E., Khosroshahi, A.A., Mortazavi, A., and Tavakolipour, H. 2012. effect of xanthan gum on textural and rheological properties of Iranian low–fat white cheese. Iranian journal of food science and technology. 33:1.45-35.

    17.Ghiyasi, F., Majzoobi, M., and Farahnaki, A. 2016. Effect of processed wheat germ on physicochemical and sensory characteristics of milk dessert. Food Science and Technology. 13:57.169-183.

    18.Ghods Rohani, M., and Rashidi, H. 2019. Improving the characteristics of spreadable processed cheese using Konjac and Xanthan gums. Journal of Food Processing and Preservation. 43:12.e14234.

    19.Ixtaina, V.Y., Martínez, M.L., Spotorno, V., Mateo, C.M., Maestri, D. M., Diehl, B.W., and Tomás, M.C. 2011. Characterization of chia seed oils obtained by pressing and solvent extraction. Journal of Food Composition and Analysis. 24:2.166-174.

    20.Johnson, J. 2019. Breakfast spreads. In Reducing Salt in Foods. Woodhead Publishing series in Food Science, Technology and Nutrition, 2nd Eddition,, Pp: 255-269.

    21.Jooyandeh, H., Rostamabadi, H.  and Goudarzi, M. 2019. Effect of psyllium husk, basil, and cress seed mucilages on rheological behavior of low-fat chocolate dairy dessert. Journal of Food Industry Research. 29:1.83-98.

    22.Khorami, M., Hosseini, P.S., and Motamedzadegan, A. 2013. The influence of basil seed gum concentration on the stability, particle size and  rheological properties of oil-in-water emulsion stabilized by whey protein isolate. electronic journal of  food processing and  preservation. 5:2.91-114.   23.Khoshtinat, K., Alvand, A., Zandi, P., Safafar, H., Mazloumi, M.T., and Sharifzadeh Ekbatani, Z. 2008. Sensory evaluation and shelf-life of low-fat and low-trans spreads. Iranian Journal of Nutrition Sciences & Food Technology. 3:2.13-22.

    24.Lanting, F., Biggel, A.J. and Reckweg, F. 1999. Dairy based spread and process of making, Washington, DC: U.S. Patent and Trademark Office. Pat Num: 5,916,608.

    25.Lee, C.L., Liao, H.L., Lee, W. C., Hsu, C.K., Hsueh, F.C., Pan, J.Q., and Chen, M.J. 2018. Standards and labeling of milk fat and spread products in different countries. Journal of food and drug analysis. 26:2.469-480.

    26.Li, Q., Xia, Y., Zhou, L., and Xie, J. 2013. Evaluation of the rheological, textural, microstructural and sensory properties of soy cheese spreads. Food and bioproducts processing, 91:4.429-439.

    27.Lopes, B.M., Lessa, V.L., Silva, B.M., and La Cerda, L.G. 2015. Xanthan gum: properties, production conditions, quality and economic perspective. J. Food Nut. Res. 54:3.185-194.‏

    28.Manakla, S. 2019. Effects of xanthan gum on physicochemical and sensory properties in black sesame spreads. Food and Applied Bioscience Journal. 7:3.41-52.

    29.Mahrooghi, M., GHODS, R.M., and Rashidi, H. 2018. investigation the effect of storage period on physical, chemical and sensory properties of spreadable process cheese produced with using Konjac Glucomannan gum (KGM) and Xanthan gum (XG). Iranian journal of food science and technology. 77: 15.57-67.

    30.Mahrooghi, M., GHODS, R.M., and Rashidi, H. 2017. The effects of hydrocolloids (konjac & xanthan) on textural properties of spreadable process chesse. Iranian journal of food science and technology. 68:14.293-306.

    31.Mazaheri-Tehrani, M., Yeganehzad, S., Razmkhah-sharabiani, S., and Amjadi, H. 2009. Physicochemical and sensory properties of peanut spreads fortified with soy flour. World Applied Sciences Journal. 7:2.192-196.

    32.Mirmajidi, A., and Abbasi, S. 2012. Effect of wheat cultivar and wheat flour ratio on physicochemical properties of samanoo. Journal of Agricultural Engineering Research (Iran). 13:1.45-56.

    33.Mofid, V., Mousavi, M., Emam-Djomeh, Z., Razavi, S.H., Gharibzahedi, S.M.T., and Jahanbakhsh, F. 2014. Studying the interaction of xanthan gum and pectin with some functional carbohydrates on the rheological attributes of a low-fat spread. Journal of dispersion science and technology. 35:8.1106-1113.

    34.Mohammad Alizade Samani, E., and Goli, M. 2019. Optimization of Mayonnaise Formula Using Hazelnut Meal Milk as Egg Yolk Substitute at Various Levels of Xanthan-Guar Gum and Response Surface Methodology. Iranian Journal Food Science and Technology Research. 14:3.75-86.

    35.Mortensen, B.K. 2016.Butter and Other Milk Fat Products: Milk fat-based spreads. Encyclopedia of Dairy Sciences, 2nd Eddition, Pp: 522-527.

    36.Mousazadeh, M., Mousavi, M., Emam-Djomeh, Z., Hadinezhad, M., and Gharibzahedi, S.M.T. 2014. Formulation optimization of pistachio oil spreads by characterization of the instrumental textural attributes. International Journal of Food Properties. 17:6.1355-1368.

    37.Nadtochii, L.A., Baranenko, D.A., Lu, W., Safronova, A.V., Lepeshkin, A.I., and Ivanova, V.A. 2020. Rheological and physical–chemical properties of yogurt with oat–chia seeds composites. Agronomy Research. 18:S3.1816-1828.

    38.Nasirpour-Tabrizi, P., Azadmard-Damirchi, S., Hesari, J., Khakbaz Heshmati, M., and Savage, G.P. 2020. Production of a spreadable emulsion gel using flaxseed oil in a matrix of hydrocolloids. Journal of Food Processing and Preservation. 44:8. e14588.

    39.Nejadmansouri, M., Shad, E., Razmjooei, M., Safdarianghomsheh, R., Delvigne, F., and Khalesi, M. 2020. Production of xanthan gum using immobilized Xanthomonas campestris cells: Effects of support type. Biochemical Engineering Journal. 15: 157.107554.‏

    40.Niknam, R., Ghanbarzadeh, B., Ayaseh, A., and Rezagholi, F. (2018). Steady shear flow and dynamic rheology of the emulsions containing ultrasound-assisted extracted Plantago major seed gum. 15:83. 281-298.

    41.Panchal, B., and Bhandari, B. 2020. Butter and Dairy Fat Spreads. P 509-532, In: Truong, T., Lopez, C., Bhandari, B., and Prakash, S. (eds), Dairy Fat Products and Functionality, Springer, Cham.

    42.Patange, D.D., Patel, A.A., Singh, R.R. B., Patil, G.R., and Bhosle, D.N. 2013. Storage related changes in ghee-based low-fat spread. Journal of food science and technology. 50:2. 346-352.

    43.Patel, J., Maji, B., Moorthy, N. H. N., and Maiti, S. 2020. Xanthan gum derivatives: review of synthesis, properties and diverse applications. RSC Advances. 10:45.27103-27136.‏

    44.Rana, M. 2019. Characterization of CHIA seed flour and wellbeing endorsing possessions. International Journal of Food Science, Nutrition and Dietetics. 8:5.419-426.

    45.Rangriz, A., Mortazavi, S.A., Khomeiri, M., and Amiri, S. 2016. Physicochemical, textural, sensory and rheological properties of low-calorie mayonnaise with dairy-based. Iranian Journal Food Science and Technology Research. 12: 1.34-48.

    46.Razavi, S.M.A., Habibi Najafi, M.B., and  Alaei Rouzbahani, Z. 2005. The
    effect of fat substitutes on the emulsion stability and sensory characteristics of reduced fat sesame paste/date syrup blends (reduced fat Halwa-Ardeh). Iranian Food Science and Technology Research Journal. 1:2.1-10.

    47.Shahabadi, S., Tavakolipour, H., Mortazavi, SA., and Raoufi, N. 2015.  Effect of carrageenan gum and partial replacement of butter with the sunflower oil on some physicochemical properties of samanu spread during storage. Journal of Food Industry Research. 25:3.392-404.

    48.Shahidi-Noghabi, M., Naji-Tabasi, S., and Sarraf, M. 2019. Effect of emulsifier on rheological, textural and microstructure properties of walnut butter. Journal of Food Measurement and Characterization. 13:1.785-792.

    49.Shakerardekani, A., Karim, R., Ghazali, H.M., and Chin, N.L. 2013. Textural, rheological and sensory properties and oxidative stability of nut spreads. International journal of molecular sciences, 14:2.4223-4241.

    50.Steffolani, E., De la Hera, E., Pérez, G., and Gómez, M. 2014. Effect of Chia (Salvia hispanica. L) Addition on the Quality of Gluten‐Free Bread. Journal of Food Quality. 37:5.309-317.

    51.Sworn, G. 2021. Xanthan gum. In Handbook of hydrocolloids. Woodhead Publishing series in Food Science, Technology and Nutrition, 3nd Eddition, Pp: 833-853.

    52.Tanti, R., Barbut, Sh., and Marangoni, A.G. 2016. Oil stabilization of natural peanut butter using food grade polymers, Food Hydrocolloids. 1:61.399-408.

    53.Zhao, Q., Zhao, M., Yang, B., and Cui, C. 2009. Effect of xanthan gum on the physical properties and textural characteristics of whipped cream. Food Chemistry. 116: 3.624-628.

    54.Zheng, H. 2019. Introduction: measuring rheological properties of Foods. P 3-30, In: Joyner, H. (eds), Rheology of Semisolid Foods, Springer, Cham.

Food Processing and Preservation Journal
Volume 14, Issue 1
September 2022
Pages 99-115

Files

Share

How to cite

Statistics